Kia Sedona: Troubleshooting

Third generation YP (2014-2024) / Kia Sedona YP Service Manual / Heating,Ventilation And Air Conditioning / Troubleshooting

Troubleshooting

Problem Symptoms Table

Before replacing or repairing air conditioning components, first determine if the malfunction is due to lack of refrigerant, air flow or compressor.

Use the following table to find the cause of the problem. The numbers indicate the order of the likely cause of the problem. Check each part in order. If necessary, replace the corresponding parts.

After fixing the area of malfunction, check the complete system to ensure satisfactory performance.

Standard:

Symptom	Suspected Area
No blower operation	1. Blower fuse
	2. Blower relay
	3. Blower motor
	4. Power mosfet
	5. Blower speed control switch
	6. Wire harness
No air temperature control	1. Engine coolant capacity
No air temperature control	2. Heater control assembly
No compressor operation	1. Refrigerant capacity
	2. A/C fuse
	3. Clutch limiter
	4. Compressor
	5. A/C pressure transducer
	6. A/C switch
	7. Evaporator temperature sensor
	8. Wire harness
Vented air not cold	1. Refrigerant capacity
	2. Refrigerant pressure
	3. Drive belt
	4. Clutch limiter
	5. Compressor
	6. A/C pressure transducer
	7. Evaporator temperature sensor
	8. A/C switch
	9. Heater control assembly
	10. Wire harness
Insufficient cooling	1. Refrigerant capacity
	2. Drive belt
	3. Clutch limiter
	4. Compressor
	5. Condenser
	6. Expansion valve
	7. Evaporator
	8. Refrigerant lines
	9. A/C pressure transducer
	10. Heater control assembly
No engine idle-up when A/C switch ON	1. Engine ECM
No engine idle-up when A/C switch ON	2. Wire harness
No air inlet control	1. Heater control assembly
No mode control	1. Heater control assembly
No mode control	2. Mode actuator
No cooling fan operation	1. Cooling fan fuse
	2. Fan motor
	3. Engine ECM
	4. Wire harness

Special Service Tools

Special Service Tools Tool (Number and name)IllustrationUse09977-3R000Disc & hub assembly bolt removerRemoval and installation of disc & hub assembly. ...

Other Information:

Headlamp (bulb type) -high/low
1. Open the hood. 2. Remove the front cover(1) and headlamp assembly nuts(2). 3. Remove the headlamp assembly from the body of the vehicle 4. Remove the headlamp bulb cover by turning it counte ...

Relay Box (Engine Compartment) Repair procedures
Inspection 1. Disconnect the negative (-) battery terminal. 2. Pull out the relay from the engine compartment relay block. Power Relay (Type A) Check for continuity between the terminals. ...

Kia Sedona: Troubleshooting

Special Service Tools

Air conditioning System

Other Information:

Categories