Kia Optima Manuals

Kia Sedona: Brake Line Repair procedures - Brake System - Brake System - Kia Sedona YP Service ManualKia Sedona: Brake Line Repair procedures

Third generation YP (2014-2024) / Kia Sedona YP Service Manual / Brake System / Brake System / Brake Line Repair procedures

Removal
1.
Disconnect the brake fiuid level switch connector, and remove the reservoir cap.
2.
Remove the brake fluid from the master cylinder reservior with a syringe.
   
Do not spill brake fluid on the vehicle as it may damage the paint. If brake fluid comes in contact with the paint, wash off immediately with water.
3.
Remove the wheel & tire.
4.
Disconnect the brake tube by loosening the tube flare nut (B).
Tightening torque:
12.7 ~ 16.7 N.m (1.3 ~ 1.7 kgf.m, 9.4 ~ 12.3 lb-ft)
Front

Rear

5.
Remove the brake hose clip (A).
6.
Disconnect the brake hose from the brake caliper by loosening the bolt (C).
Tightening torque:
24.5 ~29.4 N.m (2.5 ~3.0 kgf.m, 18.1 ~21.7 lb-ft)
Front

Rear

Inspection
1.
Check the brake tubes for cracks, crimps and corrosion.
2.
Check the brake hoses for cracks, damage and fluid leakage.
3.
Check the brake tube flare nuts for damage and fluid leakage.
4.
Check brake hose mounting bracket for crack or deformation.
Installation
1.
Install in the reverse order of removal.
   
Use a new washer (A) whenever installing.

2.
After installation, bleed the brake system.
(Refer to Brake system - "Brake system Bleeding")
3.
Check for spilled brake fluid.
Brake Line Components and Components Location
Components ...

Brake Pedal Components and Components Location
Components 1. Cowl bracket2. Brake pedal member assembly3. Brake switch4. Return spring5. Brake pedal stopper6. Clevis pin7. Snap pin8. Brake pedal ...

Other Information:

Rear Door Power Window Regulator Repair procedures
Replacement 1. Remove the rear door window glass. (Refer to Rear Door - "Rear Door Window Glass") 2. Loosen the mounting nut and remove the rear door power window regulator connector (A). ...

OFF mode
Press the front blower OFF button to turn off the front air climate control system. However, you can still operate the mode and air intake buttons as long as the ignition switch is in the ON pos ...

Categories


Copyright В© www.kisedona.com 2016-2024