Kia Sedona: ESC Control Module Repair procedures - ESC(Electronic Stability Control) System - Brake System - Kia Sedona YP Service ManualKia Sedona: ESC Control Module Repair procedures

Third generation YP (2014-2024) / Kia Sedona YP Service Manual / Brake System / ESC(Electronic Stability Control) System / ESC Control Module Repair procedures

Removal
1.
Turn the ignition switch OFF.
2.
Remove the brake fluid from the master cylinder reservoir with a syringe.
   
•
Be sure to completely remove foreign substances from around brake fluid reservoir and cap before opening the reservoir cap. Otherwise, it may cause contamination of brake fluid and deterioration in braking performance.
•
Do not spill brake fluid on the vehicle as it may damage the paint. If brake fluid comes in contact with the paint, wash off immediately with water.
3.
Pull up the lock of the HECU connector (A) and then disconnect the connector.

4.
Disconnect the brake tubes from the HECU by unlocking the nuts counterclockwise with a wrench.

Tightening torque:
A : 12.7 ~ 16.7 N.m (1.3 ~ 1.7 kgf.m, 9.4 ~ 12.3 lb-ft)
B : 18.6 ~ 22.6 N.m (1.9 ~ 2.3 kgf.m, 13.7 ~ 16.6 lb-ft)

5.
Loosen the HECU bracket nuts (A) and then remove HECU and bracket.

Tightening torque :
16.7 ~ 25.5 N.m (1.7 ~ 2.6 kgf.m, 12.3 ~ 18.8 lb-ft)

   
1)
Never attempt to disassemble the HECU.
2)
Never shock the HECU.
6.
Remove the bolts and then remove the bracket from HECU.

Tightening torque :
10.8 ~ 13.7 N.m (1.1 ~ 1.4 kgf.m, 8.0 ~ 10.1 lb-ft)

Installation
1.
Install in the reverse order of removal.
2.
Tighten the HECU mounting bolts and nuts to the specified torque.
3.
After installation, bleed the brake system.
(Refer to Brake system - "Brake system Bleeding")
ESC Control Module Components and Components Location
Components 1. Front - left tube2. Rear - right tube3. Rear - left tube4. Front - right tube5. MC26. MC17. ESC control module (HECU)8. Bracket ...

Front Wheel Speed Sensor Components and Components Location
Components 1. Front wheel speed sensor2. Front wheel speed sensor connector ...

Other Information:

Weight of the trailer tongue
The tongue load of any trailer is an important weight to measure because it affects the total gross vehicle weight (GVW) of your vehicle. This weight includes the curb weight of the vehicle, any ...

Components and Components Location
Components 1. Front seat center side cover [LH]2. Front seat cushion vent mat [LH]3. Front seat cushion pad assembly [LH]4. Front seat cushion cover assembly [LH]5. Front seat cushion frame assem ...

Categories


Copyright © www.kisedona.com 2016-2024